• 技術中心
    Technology Center
    當前位置:網站首頁 > 技術中心 > 技術詳情
    使用注意事項
    2017-06-16 16:28

    棚板在運輸和儲存時,就保持直立置放禁止疊放.在任何情況下應保持棚板干燥.

    本廠棚板表面噴涂的白色涂料經燒結后,正??墒褂茫常秱€月,如表面白色涂料需更換,可使用本廠調配的涂料,在噴涂前盡可能將舊涂料面清除干凈后,再以噴槍噴刷施工,厚度為0.4-0.6mm為宜.

    噴涂施工后的棚板,待其完全干燥后,方可使用.

    坯體置于棚板上,需特別注意坯體需完全干燥,產品底部接觸棚板部分,就將釉料擦拭干凈,以免粘瓷.

    臺車裝載時,耐火柱宜保持一直線,以免因支撐點不同,而影響棚板的壽命.

    臺車裝載時棚板與棚板之間的距離,視坯體高度給予保留適當空隙,10-20mm為宜,坯與坯之間也需保留適當間隙,不可擠在一起或集中在某處,使窯內燃燒的火焰及空氣對流更加順暢.

    棚板正常使用時切忌急速冷及急速熱升溫,以免棚板龜裂,因此在燒成時間及溫度的設定應特別注意.

    用戶在使用過程中如有疑問,請及時與我們或供應商聯系,我們良好的售后服務一定會使您滿意.

     

    Shed boards are kept upright during transportation and storage, and are not allowed to be stacked. In any case, the shed should be kept dry.

    After sintering, the white paint sprayed on the surface of our factory can be used normally for 3-6 months. If the white paint on the surface needs to be replaced, we can use the paint prepared by our factory to remove the old paint as much as possible before spraying. Then spray gun construction, the thickness is suitable for 0.4-0.6mm.

    After spraying the construction of the shed board, it can be used only after it is completely dry.

    The green body is placed on the shed. Special attention should be paid to the complete drying of the green body. The bottom of the product contacts the shed, so wipe the glaze clean to avoid sticking to the porcelain.

    When the trolley is loaded, the refractory column should be kept in a straight line, so as not to affect the life of the slab due to different support points.

    When the trolley is loaded, the distance between the slab and the slab is determined by the height of the blank, and the appropriate gap is 10-20mm. The appropriate gap between the blank and the blank should also be retained. Make the flame and air convection burning in the kiln smoother.

    Avoid rapid cooling and rapid heating when the shed board is in normal use to avoid cracking of the shed board, so special attention should be paid to the setting of firing time and temperature.

    If you have any questions during use, please contact us or the supplier in time. Our good after-sales service will make you satisfied.

    產品推薦 Product recommend
    欧洲色,337P大尺度啪啪人体,欧美 亚洲 日韩 国产 综合 视频